PLC-Based Electronic Load Controller Using Binary Combination Switch for PLTMH Frequency Control

Authors

  • Widodo Pudji Muljanto Teknik Elektro Institut Teknologi Nasional Malang
  • Fajar Anjar Ningrum Teknik Elektro Institut Teknologi Nasional Malang
  • Irrine Budi Sulistiawati Teknik Elektro Institut Teknologi Nasional Malang

DOI:

https://doi.org/10.32492/nucleus.v5i2.5212

Keywords:

pltmh, electronic load controller, pid, zelio smart relay, binary combination switch

Abstract

Micro-hydro power plants (PLTMH) need effective frequency regulation to maintain operational stability during electrical load changing. This research presents the design and experimental evaluation of a Programmable Logic Controller (PLC)-based Electronic Load Controller (ELC) using an 8-bit Binary Combination Switch (BCS) and Proportional-Integral-Derivative (PID) control for generator frequency regulation. The system utilizes a Zelio Smart Relay PLC to process generator frequency errors and control binary-weighted resistive dummy loads via relay combinations. Experimental testing was conducted on a 1.1 kVA three-phase synchronous generator under load increments of 100 W, 200 W, and 300 W Test results indicate minimum frequency values of 49.8 Hz, 49.5 Hz, and 49.1 Hz, while maximum transient frequencies reached 50.5 Hz, 50.4 Hz, and 50.4 Hz. Maximum overshoot values were recorded at 1.0%, 0.8%, and 0.8%, with steady-state errors of 0.2%, 0.2%, and 0.4%, respectively. The frequency operating range of 49–51 Hz centered around the 50 Hz reference value; results show the system achieved stable operation approximately 30 seconds after the final load disturbance. The study demonstrates that the proposed PLC-based ELC is capable of regulating dummy load power through discrete binary relay combinations and maintaining the generator frequency close to the reference value under the tested load conditions

References

L. N. Rahayu dan J. Windarta, “Tinjauan Potensi dan Kebijakan Pengembangan PLTA dan PLTMH di Indonesia,” J. En. Baru & Terbarukan, vol. 3, no. 2, hlm. 88–98, Jun 2022, doi: 10.14710/jebt.2022.13327.

S. J. W. Klein dan E. L. B. Fox, “A review of small hydropower performance and cost,” Renewable and Sustainable Energy Reviews, vol. 169, hlm. 112898, Nov 2022, doi: 10.1016/j.rser.2022.112898.

T. Mosetlhe, A. Yusuff, T. Ayodele, dan A. Ogunjuyigbe, “Sustainable rural electrification through micro-grids in developing nations — A review of recent development,” Energy Reports, vol. 13, hlm. 1171–1177, Jun 2025, doi: 10.1016/j.egyr.2024.11.040.

A. Deliana Siregar, J. Juventa, D. M. M. Ritonga, N. Larasati, dan S. Annura Rizky, “Potensi Sumberdaya Air Sebagai Pembangkit Listrik Tenaga Mikrohidro (pltmh) Dalam Mencapai Sustainable Development Goals (sdgs) Di Desa Rantau Kermas, Kecamatan Jangkat, Kabupaten Merangin, Provinsi Jambi,” JoP, vol. 9, no. 1, hlm. 80–84, Nov 2023, doi: 10.22437/jop.v9i1.28577.

N. Rospriandana, P. J. Burke, A. Suryani, M. H. Mubarok, dan M. A. Pangestu, “Over a century of small hydropower projects in Indonesia: a historical review,” Energ Sustain Soc, vol. 13, no. 1, hlm. 30, Agu 2023, doi: 10.1186/s13705-023-00408-1.

N. Sanampudi dan P. Kanakasabapathy, “Integrated voltage control and frequency regulation for stand-alone micro-hydro power plant,” Materials Today: Proceedings, vol. 46, hlm. 5027–5031, 2021, doi: 10.1016/j.matpr.2020.10.403.

A. J. Veronica dan N. S. Kumar, “Control strategies for frequency regulation in microgrids: A review,” Wind Engineering, vol. 45, no. 1, hlm. 107–122, Feb 2021, doi: 10.1177/0309524X19868425.

R. R. Singh, B. A. Kumar, D. Shruthi, R. Panda, dan C. T. Raj, “Review and experimental illustrations of electronic load controller used in standalone Micro-Hydro generating plants,” Engineering Science and Technology, an International Journal, vol. 21, no. 5, hlm. 886–900, Okt 2018, doi: 10.1016/j.jestch.2018.07.006.

R. A. Ofosu, K. K. Kaberere, J. N. Nderu, dan S. I. Kamau, “Design of BFA-optimized fuzzy electronic load controller for micro hydro power plants,” Energy for Sustainable Development, vol. 51, hlm. 13–20, Agu 2019, doi: 10.1016/j.esd.2019.04.003.

S. Sofyan, K. Naim, dan M. A. Basri, “Rancang Bangun Electronic Load Control Generator pada Pembangkit Listrik Tenaga Mikro Hidro Berbasis Mikrokontroler dan IoT,” ELEKTERIKA, vol. 19, no. 1, hlm. 23, Mei 2022, doi: 10.31963/elekterika.v6i1.3397.

E. R. Alphonsus dan M. O. Abdullah, “A review on the applications of programmable logic controllers (PLCs),” Renewable and Sustainable Energy Reviews, vol. 60, hlm. 1185–1205, Jul 2016, doi: 10.1016/j.rser.2016.01.025.

B. Herdiana, E. B. Setiawan, dan U. Sartoyo, “Tinjauan Komprehensif Evolusi, Aplikasi, dan Tren Masa Depan Programmable Logic Controllers (A Comprehensive Review of the Evolution, Applications, and Future Trends of Programmable Logic Controllers),” Jurnal Ilmiah Telekomunikasi, Kendali dan Elektronika Terapan, vol. 11, no. 2, hlm. 173–193, Jul 2024, doi: 10.34010/telekontran.v11i2.12896.

A. F. Obele, D. O. Aikhuele, dan H. U. Nwosu, “A review of reliability techniques for the evaluation of Programmable logic controller,” WJEEE, vol. 3, no. 1, hlm. 24–57, Mar 2024, doi: 10.31586/wjeee.2024.947.

H. Bory, L. Vazquez, H. Martínez, dan Y. Majanne, “Evaluation of the Symmetrically Switched Converter Structures on the Frequency Regulation of Standalone Micro Hydro Power Plants,” IFAC-PapersOnLine, vol. 55, no. 9, hlm. 70–75, 2022, doi: 10.1016/j.ifacol.2022.07.013.

A. Ali, Arshad, H. Akhtar, M. U. R. Siddiqi, dan M. Kamran, “An efficient and novel technique for electronic load controller to compensate the current and voltage harmonics,” Engineering Science and Technology, an International Journal, vol. 23, no. 5, hlm. 1042–1057, Okt 2020, doi: 10.1016/j.jestch.2019.11.009.

I. Mardiyanto, “Design and Simulation of Electronic Load Controller with DC Dummy Load on Run Off River Type Micro Hydro Power Plant,” International Journal of Applied Technology Research (IJATR), vol. 5, no. 3, hlm. 1–11, Feb 2025.

R. Syahputra dan I. Soesanti, “Renewable energy systems based on micro-hydro and solar photovoltaic for rural areas: A case study in Yogyakarta, Indonesia,” Energy Reports, vol. 7, hlm. 472–490, Nov 2021, doi: 10.1016/j.egyr.2021.01.015.

T. Utomo, L. Ardhenta, dan R. Y. At Tamimi, “Rancang Bangun ELC (Electronic Load Controller) sebagai Pengendali Beban PLTMH (Pembangkit Listrik Tenaga Mikrohidro) Kali Jari,” jeeccis, vol. 15, no. 2, hlm. 36–42, Agu 2022, doi: 10.21776/jeeccis.v15i2.1541.

T. As, M. Marhatang, Z. Natsir, dan N. Paelongan, “Rancang Bangun Sistem Electronic Load Controller (elc) Pada Pltmh Pallawa (kab. Bone),” Sinergi, vol. 20, no. 2, hlm. 259–268, Okt 2022, doi: 10.31963/sinergi.v20i2.4166.

I. K. Duah, C. K. K. Sekyere, F. Kemausuor, dan K. A. Amaning, “Micro hydropower research and practice over the last decade for advancing decentralized energy access,” Discov Sustain, vol. 7, no. 1, hlm. 128, Des 2025, doi: 10.1007/s43621-025-02375-3.

M. Kusriyanto, H. S. Utama, dan I. Effendi, “Prototype of Automatic Frequncy Control in Microhydro Power Plant with Dummy Load Based on Arduino Uno and Labview,” Teknoin, vol. 27, no. 1, Mar 2021, doi: 10.20885/teknoin.vol27.iss1.art1.

W. B. Mursanto, M. A. P. Purnama, dan A. Pudin, “Rancangan electronic load control 1 fasa pada simulator pembangkit listrik tenaga piko hidro,” JITEL, vol. 3, no. 2, hlm. 101–110, Agu 2023, doi: 10.35313/jitel.v3.i2.2023.101-110.

Downloads

Published

2026-09-17

How to Cite

Muljanto, W. P., Fajar Anjar Ningrum, & Sulistiawati, I. B. (2026). PLC-Based Electronic Load Controller Using Binary Combination Switch for PLTMH Frequency Control. Nucleus Journal, 5(2), 383–393. https://doi.org/10.32492/nucleus.v5i2.5212

Issue

Section

Articles